Parker Velcon Aquacon ACO Outside-to-inside Flow Fuel Filter MonitorAquacon® ACO-P Fuel Monitors

EI1583 7th Edition "R Series" Qualified Water Absorbing "Monitor" Cartridges

Outside-to-In Flow Datasheet - VEL1681

ACO Series - Outside-to-In Flow Cartridges

Remove Water and Dirt from Jet Fuel and Avgas

Description

Patented Aquacon® Filter Cartridges have a unique high-capacity inner filter media which removes all free and emulsified water from hydrocarbon fuels down to less than 5 ppm in the effluent. Absorbed water is chemically locked into this media.

When a cartridge reaches its water holding capacity, its accordion pleats swell and cause an increase in the differential pressure which signals the operator to change the cartridge.

Solid contaminants are removed by the cartridge’s two particulate filter media layers. The pleated accordion style design provides a large surface area for maximum dirt holding capacity. Models are offered for particulate filtration down to 1/2 micrometer size with 98% plus efficiency. Performance is not affected by the presence of common surface active agents.

Compact Aquacon® Cartridges are quick and easy to install. Models are available to fit most existing standard housings. Refer to Cartridge Selection Table on below.

*****CAUTION*****
DO NOT USE WITH PRE-MIXED FUELS CONTAINING
ANTI-ICING ADDITIVES.

Use form VEL1846 for cartridge change out at flowrates less than rated flow.

ACO-P Series Cartridge Selection Table

Model
Number
Micron
Ratings
Inside
Diameter
(in)
Outside
Diameter
(in)
Length
(in)
Collapse
Pressure
(psi)
Maximum
Flow
Rate (USGPM)
Interchange Information
ACO-21001R 0.5 1 1/32 2 5/8 9 3/4 60 15 Fits VF-31E Housing
ACO-31001R 0.5 1 5/16 3 9 3/4 75 20 Fits Purolator Vessel PR-172-3
ACO-40801R 0.5 1 3/4 4 8 100 13 Rellumit Replacement
ACO-41201R 0.5 1 3/4 4 12 1/4 100 20 Replaces Facet C-707;
Purolator Vessel PAG-50
ACO-41601R 0.5 1 3/4 4 15 13/16 100 27 Rellumit Replacement
ACO-41801R 0.5 1 3/4 4 18 100 30 Replaces Facet C-706 and
Keene BP-419, BP-518
ACO-41901R 0.5 1 3/4 4 19 7/8 175 32 Rellumit Replacement
ACO-51201R 0.5 1 7/8 5 5/8 12 1/4 75 50 Fits VF-61 Housing
ACO-512P3R 0.3 1 7/8 5 5/8 12 1/4 75 50 Fits VF-61 Housing
ACO-52401R 0.5 1 7/8 5 7/8 24      
ACO-60801R 0.5 3 1/2 6 8 1/4 100 30 Omeco 6” x 8” Replacement
ACO-60901R 0.5 1 1/2 6 9 11/16 100 36 Fits Fram/Facet VFCS-21
(Element CC-21-7); VF-609
ACO-60905R 0.5 1 1/2 6 9 11/16 100 36 Fits Fram/Facet VFCS-21
(Element CC-21-7); VF-609
ACO-609P3R 0.3 1 1/2 6 9 9/16 100 36 Fits Fram/Facet VFCS-21
(Element CC-21-7); VF-609
ACO-61201R 0.5 1 1/2 6 13 3/4 100 48 Fits Fram/Facet VFCS-22
(Element CC-22-7)
ACO-61401R 0.5 3 1/2 6 14 1/2 175 58 Qualified to EI 1583 6th Edition
ACO-62201RTB 0.5 3 1/2 6 22 175 88 Qualified to EI 1583 6th Edition
ACO-62901R 0.5 3 1/2 6 28 3/4 175 115 Qualified to EI 1583 6th Edition
ACO-63301R 0.5 3 1/2 6 33 1/4 175 133 Qualified to EI 1583 6th Edition
ACO-64401R 0.5 3 1/2 6 43 1/4 175 173 Qualified to EI 1583 6th Edition
ACO-64401RTB 0.5 3 1/2 6 44 175 176 Qualified to EI 1583 6th Edition
ACO-71801R 0.5 2 1/2 6 1/4 18 75 65 Fits VF-71E Housing

NOTE: 0.5 micron rated Aquacon® Cartridges are recommended for use with jet fuel and avgas. Effluent fuel quality meets requirements for EI 1583.

Technical Information

  1. Maximum operating temperature is 160°F
  2. Micron ratings are nominal at 98%+ efficiency
  3. Aquacon® Cartridges can significantly reduce flow when loaded with water or dirt. Appropriate precautions should be taken in applications where fuel flow must be maintained or where surge conditions can occur.
  4. Replace the cartridge if the differential pressure exceeds 25 psid. For service life information, please refer to Operating Procedure #1839 or consult your company fuel handling procedures.
  5. Typical water holding capacity for ACO-61401P is 700 ml.